Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA032  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  YANNI'S CAFE Address  145 N MAIN
Owner or Operator   VALAVERIS, HELEN City   MANTENO Zip Code   60950
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
X
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
X
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
X
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
X
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   split pea 150, sausage 41, gravy 138, oatmeal 147, sausage gravy 140, raw hamburger 37, corn beef 37, sausage 38
 
General Comments
 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/27/2012 Time In  10:15 AM Time Out  11:45 AM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA032  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  YANNI'S CAFE Address  145 N MAIN
Owner or Operator   VALAVERIS, HELEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1. Chicken noodle 123F. 2. cheese found at 49F.Provide for all cold potentially hazardous foods to be held at 41°F or below or above 135F at all times except during necessary periods of preparation. 750.120 Immediate/Onsite
*12  Observed an employee drink/drinking in the following location(s). Employee drink was stored on prep table. The consumption of food/drink shall be done in a designated area only. 750.280 Immediate/Onsite
2  Observed the following food products to have improper/no labeling information. There was no label on soups,gravies in the wal-in cooler. Provide for all foods to have proper labeling information Next Inspection
8  Observed the following food products to be improperly stored. There is no covers on soups & gravies. Provide for all food products to be stored at least six inches off of the floor Next Inspection
14  Observed the following improper food contact surfaces.1. Shelves have rust on them in the walk-in cooler. 2. Cutting boards have knife grooves in them. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.650 Next Inspection
22  Observed the following food contact surfaces to be unclean. Cutting boards have food stains on them. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. Fryers have grease and food debris in them & on sides of fryers. 2. Seal gasket on True refrigerator. Clean and maintain Next Inspection
24  Observed cleaned and sanitized equipment to be handled in a manner that is condusive to causing contamination. Knives were stored in between prep tables. Cleaned and sanitized equipment and utensils shall be handled in a way that protects them from contamination. 750. 860 Next Inspection
34  Observed the dumpster area to be unclean Provide for the dumpster area to be kept clean so as to not be an attactive nuisance. 750.1150 Next Inspection
36  Observed the following floor areas to be unclean: Floor under fryers has grease & food debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
37  Obseved the following wall/ceilings, and attached equipment to be unclean: 1. Ceiling tiles have been damaged by water. Provide for all walls, ceilings, and attached equipment to be in a clean condition. 750.1220 Next Inspection
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/27/2012 Time In  10:15 AM Time Out  11:45 AM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA032  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  YANNI'S CAFE Address  145 N MAIN
Owner or Operator   VALAVERIS, HELEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/27/2012 Time In  10:15 AM Time Out  11:45 AM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  88